Improving the handbrake

Replica owners or enthusiasts are very welcome

Moderator: Bootsy

Post Reply
bonerp
DDK slapper chatter
Posts: 440
Joined: Mon Jun 21, 2010 9:16 am

Improving the handbrake

Post by bonerp »

Lets face it, the balance bar set up with the cable clamps is crap to say the least.

What have you guys got/done to improve this?

thanks
Paul
Built a Pilgrim Speedster...only down one kidney

My build: https://sites.google.com/site/bonerp356/home

http://www.Speedsterclinic.co.uk

Now for sale! Next project looms...
mdmax72
Put a fork in me, I'm done!
Posts: 1512
Joined: Thu Sep 28, 2006 8:23 pm
Location: midlands u.k

Post by mdmax72 »

Paul,
not had a problem with the balance on mine, but l do have disks on the rear. When l had drums the balance was still good. Have you got the proper shortend cables with adjuster nuts behind the handbrake lever to balance?? i've seen some diy shortend cables with a u shaped clamp, so l guess would be harder to balance

R
Rich

DDK Member 0547

Evolving Speedster Build ;-)
bonerp
DDK slapper chatter
Posts: 440
Joined: Mon Jun 21, 2010 9:16 am

Post by bonerp »

Anyone know of a donor where I could use an under dash handbrake pull? Did old XJ12's use these - if I remember correctly?

I'm thinking of ditching the centre tunnel handbrake and using a pull brake.

Any suggestions welcome.
Built a Pilgrim Speedster...only down one kidney

My build: https://sites.google.com/site/bonerp356/home

http://www.Speedsterclinic.co.uk

Now for sale! Next project looms...
Little b@st@rd
DDK Fanatic
Posts: 80
Joined: Thu Feb 03, 2011 2:31 pm
Location: London

Post by Little b@st@rd »

I'd like to know this too, I've seen a couple of speedster replicas that have had this done and it looks great, adding a real touch of authenticity. Didn't some early beetles have an under dash hanbrake set up?
356california
DDK Fanatic
Posts: 99
Joined: Sun Jan 16, 2011 2:00 pm
Location: wolverhampton

Post by 356california »

If you can find one, try an oldish merc. i know early e class's and ML's used the pull handbrake system with a push down footbrake. Also early Lexus models had them too. Best place would probably be a salvage yard.

Not had any problems with mine as long as its serviced regularly.
/Users/steve/Desktop/random/250620101650.jpg
speedstars
DDK Fanatic
Posts: 55
Joined: Tue Jan 11, 2011 10:05 am
Location: milton Keynes
Contact:

Post by speedstars »

Hi,

underdash handbrakes, aren`t too tricky, but you will need a certain amount of access to the centre tunnel ie. cutting lumps out of it. My first attempt involved a camper underdash handbrake, and a golf handbrake cable. It worked, but wasn`t brilliant.
Attempt two, works brilliantly. You need to use a 356 handbrake and the actuating arm. Use standard length handbrake cables and cross piece. Drill out the cente of the cross piece and fit a long length of 8mm studding.
Fit the handbrake under the dash, drill the hole for the cable from the handbrake through the bulkhead.
Under the wheel arch drill a hole probably about 2" through the centre tunnel.
The actuating arm needs to be modified to use. Cut the upright in half, turn it around and weld back on. This gives you the movement you need. The tube section, will hit on the master cylinder. Cut it where it does, move it out by 2" and weld piece of angle iron underneath. Voila, clearance.
Fabricate a bracket for inside the tunnel for the other end of the round tube. Bolt In. Bolt a piece of angle iron on for the outside bracket, mount to the torsion tube at the front, with an exhaust clamp.
Fit the 8mm studding to the hole in the round tube inside the tunnel, and adjust.
You will also need to reweld the handrake conduit lower in the tunnel as the cable is now basically at floor level.
Make up a plate with a hole in it, and a rubber seal for where the round tube enters the tunnel from the under the wing.
You will obviously need to cut holes in the tunnel, one where the cross piece is, for adjustment, one at at the front for fitting the actuator.
These pics might help.
[/img]Image
Image
[/img]Image
Image
[/img]
It`s easier to do, than write about!
Michael Kempster

http://www.speedstars.co.uk

`58 Porsche 356A Speedster Replica
`63 Beetle 1200
`86 Porsche 944
`58 NSU Prima D Scooter
Drive `em like you`ve stolen `em
Park `em like you`ve abandoned `em
kitchens
DDK slapper chatter
Posts: 330
Joined: Thu May 24, 2007 11:06 pm
Location: east-kilbride
Contact:

Post by kitchens »

See the picture of the one fitted in my car ..no idea how it works will leave that to the experts on here .
Post Reply